Dongguan Linkun Electronic Technology Co., Ltd. |
Verified Suppliers
|
|
Sensitivity Is High Small Size 3D-13 NTC Type Thermistor Strong
Overload Capacity
Specification 0f NTC Thermistor for Current Suppression
PART NO : NTC 3D-13
1. DIMENSIONS:(mm)
Dmax | Lmin | C±1 | Tmax | d±0 .05 | Fmax |
14.5 | 25 | 7.5 | 5 | 0.7 | 4.0 |
1-1.Materil of coating :Silicon
1-2.Materil of Leads :Tinned copper wires
1-3.Color 0f Coating :Black
2-1
MAX. Permissible working current (A) |
Thermal Dissipation constant (mw/℃) |
Thermal Time constant (S) |
Operatian Temp
(℃) |
6.0 | 14 | 60 | -40~+200 |
2-2(V-I)Test
Resistance at 25℃
|
Permissible working current (A) |
Resistance under Load (mΩ) |
Test Conditions |
3Ω±20% Thermistor to be put in 25℃ oil bath | 6 | 112 | .Thermistor must be tested by current power supply. |
3.Mechanical Sharacteristics:
Item | Conditions | test result |
Tensile Strength of Terminals | Fasten body with a Load Applied to each lead 3.0Kg for 1sec. | No break out and damage |
Bending Strength of terminals | Fixed body hand 1.0kg on one terminal bend 90 then back again oppsite. |
No break out and damage |
Solder ability | When the Lead wire was dipped into bath 0f 235±5℃ for 3 seconds after immersion in 25% rosin flux the solder ability ratio of lead wire surface should more than 95%. | more than 95% solder ability |
4.Reliability Test
Item | Test Conditions | Variable |
Temp. Cycle Test
|
-85℃×→+25℃×3min |
|
Humidity Test
| 45℃ 95%RH×1000 hours |
|
Load Life
| 6 AMP×1000 hours |
|
Insulation Test
| DC 700V | R≥500MΩ |
Packing Specifiction
Part NO:NTC 3D-13
Packing |
QTY |
N.W |
G.W | LXWXH (mm) |
Polybag | 500 PCS | |||
Small-box | 5 bag | |||
Out-box | 20 s-box | 25Kg | 26Kg | 380X290X210 |
How a thermistor works
When the thermistor is installed in the circuit for use, when the
thermistor is at the same ambient temperature, the action time is
shortened sharply as the current increases; the thermistor has a
shorter action time and a smaller temperature when the ambient
temperature is relatively high. The maintenance current and
operating current. When the circuit is working normally, the
temperature of the thermistor is close to room temperature and the
resistance is very small, and the series connection in the circuit
will not hinder the passage of current; and when the circuit has an
overcurrent due to a fault, the temperature of the thermistor will
rise due to the increase in heating power. When the temperature
exceeds the switch temperature, the resistance will increase
sharply instantly, and the current in the loop will quickly
decrease to a safe value.
The main features of a thermistor are as follows.
(1) The sensitivity is high, the temperature resistance coefficient is large, and its temperature coefficient of resistance is 10 to 100 times larger than that of metals, and it can detect temperature changes of 10-6 °C.
(2) The working temperature range is wide, the normal temperature device is suitable for -55~315°C, the high temperature device is suitable for a temperature higher than 315°C (currently the highest can reach 2000°C, and the low temperature device is suitable for -273~55°C.
(3) The structure is simple, the volume is small, and it can measure the temperature of voids, cavities, and blood vessels in organisms that cannot be measured by other thermometers.
(4) Easy to use, the resistance value can be arbitrarily selected between 0.1~100kΩ.
(5) It is easy to process into complex shapes and can be mass-produced.
(6) Good stability and strong overload capacity.
(7) High resistivity, small thermal inertia, suitable for dynamic measurement. However, the resistance value has a nonlinear relationship with temperature changes, stability and interchangeability
P/N | R@25℃ | Tolerance(%) | Beta Value | Tolerance(%) |
MF11-050 | 5 | ±5 ±10 ±20 | 2400 | ±5 ±10 |
MF11-100 | 10 | 2800 | ||
MF11-150 | 15 | 2800 | ||
MF11-200 | 20 | 2800 | ||
MF11-220 | 22 | 2800 | ||
MF11-270 | 27 | 3000 | ||
MF11-330 | 33 | 3000 | ||
MF11-390 | 39 | 3000 | ||
MF11-470 | 47 | 3100 | ||
MF11-500 | 50 | 3100 | ||
MF11-680 | 68 | 3100 | ||
MF11-820 | 82 | 3100 | ||
MF11-101 | 100 | 3200 | ||
MF11-121 | 120 | 3200 | ||
MF11-151 | 150 | 3200 | ||
MF11-201 | 200 | 3200 | ||
MF11-221 | 220 | 3500 | ||
MF11-271 | 270 | 3500 | ||
MF11-331 | 330 | 3500 | ||
MF11-391 | 390 | 3500 | ||
MF11-471 | 470 | 3500 | ||
MF11-501 | 500 | 3500 | ||
MF11-561 | 560 | 3500 | ||
MF11-681 | 680 | 3800 | ||
MF11-821 | 820 | 3800 | ||
MF11-102 | 1000 | 3800 | ||
MF11-122 | 1200 | 3800 | ||
MF11-152 | 1500 | 3800 | ||
MF11-202 | 2000 | 4000 | ||
MF11-222 | 2200 | 4000 | ||
MF11-272 | 2700 | 4000 | ||
MF11-302 | 3000 | 4000 | ||
MF11-332 | 3300 | 4000 | ||
MF11-392 | 3900 | 4000 | ||
MF11-472 | 4700 | 4050 | ||
MF11-502 | 5000 | 4050 | ||
MF11-562 | 5600 | 4050 | ||
MF11-682 | 6800 | 4050 | ||
MF11-822 | 8200 | 4050 | ||
MF11-103 | 10000 | 4050 | ||
MF11-123 | 12000 | 4050 | ||
MF11-153 | 15000 | 4150 | ||
MF11-203 | 20000 | 4300 | ||
MF11-303 | 30000 | 4300 | ||
MF11-473 | 47000 | 4300 | ||
MF11-503 | 50000 | 4300 | ||
MF11-683 | 68000 | 4300 | ||
MF11-104 | 100000 | 4500 | ||
MF11-124 | 120000 | 4700 | ||
MF11-154 | 150000 | 4700 | ||
MF11-204 | 200000 | 4700 | ||
MF11-304 | 300000 | 4700 | ||
MF11-504 | 500000 | 4800 | ||
MF11-105 | 1000000 | 4900 |
Applications
Coversion power-supply, switch power, ups power
Electronic energy saving lamps,electronic ballast and all kinds of
electric heater
All kinds of RT, display
Bulb and other lighting lamps
Part No.Mf72 | R25 | Max,Steady Stale Current(A) | Approx. R of Maz.Cur. | Dissi.Coef.(MW/℃) | Thermal time Constant(S) | Operating Temp.(℃) |
5D5 | 5 | 1 | 0.353 | 6 | 20 | -55~+200 |
10D5 | 10 | 0.7 | 0.771 | 6 | 20 | |
60D5 | 60 | 0.3 | 1.878 | 6 | 18 | |
200D5 | 200 | 0.1 | 18.70 | 6 | 18 | |
5D7 | 5 | 2 | 0.283 | 10 | 30 | |
8D7 | 8 | 1 | 0.539 | 9 | 28 | |
10D7 | 10 | 1 | 0.616 | 9 | 27 | |
12D7 | 12 | 1 | 0.816 | 9 | 27 | |
16D7 | 16 | 0.7 | 1.003 | 9 | 27 | |
22D7 | 22 | 0.6 | 1.108 | 9 | 27 | |
33D7 | 33 | 0.5 | 1.485 | 10 | 28 | |
200D7 | 200 | 0.2 | 11.65 | 11 | 28 | |
3D9 | 3 | 4 | 0.120 | 11 | 35 | |
4D9 | 4 | 3 | 0.190 | 11 | 35 | |
5D9 | 5 | 3 | 0.210 | 11 | 34 | |
6D9 | 6 | 2 | 0.315 | 11 | 34 | |
8D9 | 8 | 2 | 0.400 | 11 | 32 | |
10D9 | 10 | 2 | 0.458 | 11 | 32 | |
12D9 | 12 | 1 | 0.652 | 11 | 32 | |
16D9 | 16 | 1 | 0.802 | 11 | 31 | |
20D9 | 20 | 1 | 0.864 | 11 | 30 | |
22D9 | 22 | 1 | 0.950 | 11 | 30 | |
30D9 | 30 | 1 | 1.022 | 11 | 30 | |
33D9 | 33 | 1 | 1.124 | 11 | 30 | |
50D9 | 50 | 1 | 1.252 | 11 | 30 | |
60D9 | 60 | 0.8 | 1.502 | 11 | 30 | |
80D9 | 80 | 0.8 | 2.010 | 11 | 30 | |
120D9 | 120 | 0.8 | 3.015 | 11 | 30 | |
200D9 | 200 | 0.5 | 5.007 | 11 | 32 | |
400D9 | 400 | 0.2 | 30.30 | 11 | 32 | |
2.5D11 | 2.5 | 5 | 0.095 | 13 | 43 | |
3D11 | 3 | 5 | 0.100 | 13 | 43 | |
4D11 | 4 | 4 | 0.150 | 13 | 44 | |
5D11 | 5 | 4 | 0.156 | 13 | 45 | |
6D11 | 6 | 3 | 0.240 | 13 | 45 | |
8D11 | 8 | 3 | 0.255 | 14 | 47 | |
10D11 | 10 | 3 | 0.275 | 14 | 47 | |
12D11 | 12 | 2 | 0.462 | 14 | 48 | |
16D11 | 16 | 2 | 0.470 | 14 | 50 | |
20D11 | 20 | 2 | 0.512 | 15 | 52 | |
22D11 | 22 | 2 | 0.563 | 15 | 52 | |
30D11 | 30 | 1.5 | 0.667 | 15 | 52 | |
33D11 | 33 | 1.5 | 0.734 | 15 | 52 | |
50D11 | 50 | 1.5 | 1.021 | 15 | 52 | |
60D11 | 60 | 1.5 | 1.215 | 15 | 52 | |
80D11 | 80 | 1.2 | 1.656 | 15 | 52 | |
1.3D13 | 1.3 | 7 | 0.062 | 13 | 52 | |
1.5D13 | 1.5 | 7 | 0.073 | 13 | 60 | |
2.5D13 | 2.5 | 6 | 0.088 | 13 | 160 | |
3D13 | 3 | 6 | 0.092 | 14 | 60 | |
4D13 | 4 | 5 | 0.120 | 15 | 67 | |
5D13 | 5 | 5 | 0.125 | 15 | 68 | |
6D13 | 6 | 4 | 0.170 | 15 | 65 | |
7D13 | 7 | 4 | 0.188 | 15 | 65 | |
8D13 | 8 | 4 | 0.194 | 15 | 60 | |
10D13 | 10 | 4 | 0.206 | 15 | 65 | |
12D13 | 12 | 3 | 0.316 | 16 | 65 | |
15D13 | 15 | 3 | 0.335 | 16 | 60 | |
16D13 | 16 | 3 | 0.338 | 16 | 60 | |
20D13 | 20 | 3 | 0.372 | 16 | 65 | |
30D13 | 30 | 2.5 | 0.517 | 16 | 65 | |
47D13 | 47 | 2 | 0.810 | 17 | 65 | |
120D13 | 120 | 1.2 | 2.124 | 16 | 65 | |
1.3D15 | 1.3 | 8 | 0.048 | 18 | 65 | |
1.5D15 | 1.5 | 8 | 0.052 | 18 | 68 | |
3D15 | 3 | 7 | 0.075 | 18 | 69 | |
5D15 | 5 | 6 | 0.112 | 18 | 76 | |
6D15 | 6 | 5 | 0.155 | 20 | 76 | |
7D15 | 7 | 5 | 0.173 | 20 | 80 | |
8D15 | 8 | 5 | 0.178 | 20 | 80 | |
10D15 | 10 | 5 | 0.180 | 20 | 80 | |
12D15 | 12 | 4 | 0.250 | 20 | 80 | |
15D15 | 15 | 4 | 0.268 | 21 | 75 | |
16D15 | 16 | 4 | 0.276 | 21 | 75 | |
20D15 | 20 | 4 | 0.288 | 21 | 85 | |
30D15 | 30 | 3.5 | 0.438 | 21 | 70 | |
47D15 | 47 | 3 | 0.680 | 21 | 86 | |
120D15 | 120 | 1.8 | 1.652 | 22 | 87 | |
0.7D20 | 0.7 | 11 | 0.018 | 24 | 89 | |
1.3D20 | 1.3 | 9 | 0.037 | 24 | 88 | |
3D20 | 3 | 8 | 0.055 | 24 | 88 | |
5D20 | 5 | 7 | 0.087 | 24 | 87 | |
6D20 | 6 | 6 | 0.113 | 25 | 103 | |
8D20 | 8 | 6 | 0.142 | 25 | 105 | |
10D20 | 10 | 6 | 0.162 | 25 | 102 | |
12D20 | 12 | 5 | 0.195 | 25 | 100 | |
16D20 | 16 | 5 | 0.212 | 25 | 100 | |
0.7D25 | 0.7 | 12 | 0.014 | 30 | 120 | |
1.5D25 | 1.5 | 10 | 0.027 | 30 | 121 | |
3D25 | 3 | 9 | 0.044 | 32 | 124 | |
5D25 | 5 | 8 | 0.070 | 32 | 125 | |
8D25 | 8 | 7 | 0.114 | 33 | 125 | |
10D25 | 10 | 7 | 0.130 | 32 | 125 | |
12D25 | 12 | 6 | 0.156 | 32 | 126 | |
16D25 | 16 | 6 | 0.160 | 35 | 126 |
Negative temperature coefficient thermistor, also known as NTC
thermistor, is a kind of sensor resistance whose resistance value
decreases with the increase of temperature. Widely used in various
electronic components, such as temperature sensors, resettable
fuses and self-adjusting heaters, etc.