Special Magnesium(Hong Kong) Industry Limited |
|
Low Polarizability Water Heater Magnesium Anode Small Density Large Capacitance
Introduction:
Water heaters usually use titanium steel or manganese steel metal liner, and then coat the enamel on the metal inner surface. Under the condition that the enamel coating on the inner surface of the metal is intact, the insulation performance between the magnesium rod and the metal liner is good, reaching the insulation resistance, which is more than 3M ohms. However, when the enamel liner is cracked locally, a resistance is formed between the magnesium anode and the metal liner through water, and the magnesium negative electrode starts to output current, and a polarizing film is generated on the exposed metal liner to repair the damaged enamel and metal.
Specification:
Product Type: | Magnesium rod |
Material: | Magnesium alloy AZ31 |
Differnet kinds: | Casting rod,Extruded rod,Rod with steel cap,Flexible anode rod |
Chemical composition: | Al:2.5-3.5%, Zn:0.6-1.4%,Mn:0.2-1.0%,Fe:0.005%max,, Cu:0.01%max,Ni:0.001%max,Si:0.1%max, Other:0.3%max,Mg:Balance |
Propertices: | Open-circuit voltage: 1.5-1.55V Close-circuit voltage:1.45-1.50V Actual capacitance: 1.105A.h/g Current efficiency:50%min |
Steel cap: | stainless steel,galvannized ,in black,coppper,etc. |
Application: | It mainly used in water heater,boiler,heat exchanger,water tank,etc. It can soften water,de-dirt residual,ensure water sanitation,water scale inhibition,protect inner tank,extend service life,etc. |
Features: | The extruded anode rod can be with or without steel core,can be with steel cap or only with screw;the size of cap/screw can be customilized by your specific requirements. Mainly different kinds of steel cap and screw available. |
Features:
Regular replacement:
Because the magnesium rod is in the water for a long time and used for a long time, the magnesium rod is continuously dissolved in the water, and finally becomes a sponge rod, and the weight is reduced. When the weight is reduced to one-third of the original weight, the magnesium rod should be replaced. Magnesium rods can generally be used for about a year. They are wearable parts and have no effect on the use of the electric water heater, but regular maintenance of the electric water heater is also a must.
Photos: