Active Member
|
[China]
Address: 8 Suyuanzhuang, Junhe Street, Baiyun District, Guangzhou, China
Contact name:Jessie LI
Guangzhou Chunke Environmental Technology Co., Ltd. |
|
|
5000TDS Brackish Water Treatment Plant Salt Water RO Machine For
Domestic Water
Reverse Osmosis System use for Seawater Desalination
Protection of reverse osmosis membrane elements
If the device must be shut down for 48 hours to a week, the
membrane element should be filled with protective fluid.
Preparation methods and steps: will the company provide protectant
bagged a bag, with product water dissolved completely, added to
fill the
product water tank cleaning, and then open the valve 1, 2, close the valve is fully open pressure regulating valve, puts selector switch
"cleaning", open the high-pressure pump, run 60 to 90 seconds, and then open the valve 2, close the valve 1, cleaning tank level reached its
lowest close automatically stop the pump, open the washing tank drain valve, the remaining solution can be ruled out.
Motor maintenance
The power supply must be 440V, 60Hz (three phase four wire) and
well grounded.
Switch on the power, the motor should start quickly and run
smoothly, otherwise the power should be cut off immediately to
check the cause -
may be the voltage is too low, the motor line connection is bad, or the load is too large, etc.
It is recommended that after the motor has been in operation for
some time, the current should be detected and compared with the
current
shown on the motor nameplate.
Selection criteria of reverse osmosis Marine water generator: the
equipment is compact in structure, reliable in performance, easy in
operation
and maintenance, the fresh water produced does not need mineralization and can be directly used for drinking.
Water making equipment production of fresh water in the water
quality meet the national drinking water quality standard
(GB5749-2006),
reverse osmosis Marine generator USES the international most advanced reverse osmosis technology, the optimized system design and
become, can direct seawater desalination into sweet health drinking water, give full consideration to the customer's requirements for design
and production equipment, including Marine seawater desalination equipment according to the particularity of the ship application and special
design, its small size, light weight, covers an area of the province, easy installation, strong adaptability, can be in narrow crowded, deck cabin,
the crew compartment, corridor space such as the installation.The equipment is easy to operate and maintain. As long as there is seawater
and electricity, fresh water can be provided immediately after starting.High desalination rate, stable performance, safe and reliable, novel and
ingenious design, avoid frequent cleaning, no environmental pollution.Considering the high salinity of seawater, the frame is made of stainless
steel, which is rustproof and corrosion resistant.
RO System configuration list
| NO. | Device Description | Origin/brand | Quantity |
| 1 | Raw water pump(CHL2-40 SS304 ) | CNP | 1 Set |
| A. Flow: 2.0m3/H Head: 29m K = 0.55kw | |||
| B. Including: inlet valve, return valve, pipe fittings and so on | |||
| 2 | Sand filter CK-1465/Ф350X1650MM | CHUNKE | 1 Set |
| A. FRP tank | CHUNKE | ||
| B. Manual Valve F56F | Runixn | 1 Set | |
| C. Top&bottom water distributor and center pipe | 1 Set | ||
| 3 | Carbon filter CK-1465/Ф350X1650MM | CHUNKE | 1 Set |
| A. FRP tank | CHUNKE | ||
| B. Manual Valve F56F | Runixn | 1 Set | |
| C. Top&bottom water distributor and center pipe | 1 Set | ||
| 4 | 5μm Cartridge filter | CHUNKE | 1 Set |
| A. Model:Ф195X500X5core material:ABS | CHUNKE | 1 Set | |
| B. 20″×5μm PP filters | China | 5pcs | |
| 5 | High pressure pump CDL2S-15 | CNP | 1 Set |
| A. Flow:2.0m3/h Head:112m | |||
| B. Material:SS304 K=1.5KW | |||
| 6 | Reverse osmosis water production: 1m3/h, desalination rate:96～99%, System water utilization: ≥ 60% | 1 Set | |
| A. Membrane housing 4040-1core SS304 | CHUNKE | 4pcs | |
| B. Membrane element 4040 | Vontron | 4pcs | |
| C. 304 Stainless steel frame | 1 Set | ||
| D. Water inlet solenoid valve | 1PC | ||
| E. Strong water solenoid valve | 1 Set | ||
| F. High pressure water inlet control valve | 1PC | ||
| G. Concentrated water flow control valve | 1 Set | ||
| 7 | Pipe fittings, valves U-PVC | China | 1 Set |
| 8 | Electronic control system | CHUNKE | 1 Set |
| Main cotrol box:PC programmable automatic control, France Schneider contactors, thermal relays, knobs, switches, lights, Korean pressure controller, time controller. | |||
| 9 | Filter Media | China | 1 Set |
| A. Quartz sand | China | 150KG | |
| B. Activated carbon | China | 50KG | |
| 10 | Pressure gauges | China | 1 Set |
| A. Reverse osmosis pressure gauge 0～25kgf/ cm2 | China | 2pcs | |
| B. High pressure pump low pressure protection switch | China | 1PC | |
| C. System pressure gauge 0～6kgf/ cm2 | China | 2pcs | |
| D. Pure water conductivity meter | China | 1 Set | |
| E. PC Program controller | China | 1 Set | |
| 11 | Flowmeter Panel type(10GPM) | China | |
| A. One stage Pure water flowmeter(Panel type 10GPM) | China | 1 Set | |
| B. One stage Strong water flowmeter(Panel type 10GPM) | China | 1 Set | |
RO System Pictures
