Anping County Xinlu Wire Mesh Products Co., Ltd. |
|
Johnson screen,Water wire screen,Water well screen, Wire warp screen,Wedge wire screen, Screen tube,Slotted tube,Wound screen,Continuous slot screen filter,Sand control screen, Wedge wire screen pipe, Rotary filter drum,Oil screen.
1. Screens with the high open area are more suitable for the
construction of high-quality water wells, oil wells, gas wells.
2. Low-cost operation Screens with high open area shall favor
groundwater infiltration. Abundant water shall reduce the water
level’s down, thus to save energy consumption
3. Reduce the abrasion of the pump Under the same condition, high
open area can make the speed of groundwater’s entering into the
screen much slower than any other filtration apparatus, which will
avoid sand entering into the screen because of high pressure, thus
reduce the abrasion of the pump.
4. Extend the life span of wells Comparatively, groundwater’s
entering into a screen with a higher open area is much easier than
entering into a lower open area screen. The slow water flow shall
extend the life span of wells.
1. Filter Gap (mm) : 0.05mm, 0.1mm. 25mm, 0.5mm, 0.63mm, 0.75mm, 1.0mm in usual. (Min slot: 0.025mm)
2. The opening area is up to 80%.
3. Material: Non-magnetic Stainless steel, low carbon steel, low carbon steel galvanized, stainless steel (201, 304, 316L, 321, 904L.) ,Duplex steel etc.
4. The length is 5.8 meters or 2.9 meters to fit container. From 100-6000mm
5. Outside diameter From 29-1300mm (Normal diameter is in the below table)
6. Connection type: Welded rings/Plain beveled ends,Male/female threaded,Flange etc.
7. Wrap wire:2*3.5mm,2.2*3.5mm,2.2*4.5mm,3*4.6mm,3*5mm,3*6mm,3*6.5mm,3*7mm etc.
8. Support rod:ø3.0-ø6.0mm round wire, Also can be Vee-shaped wire.
9. Use:Water Well,Waste Water Treatment,Water supply systems,Coal & Mine, Food Processors & Beverage Screens,Environmental protection,Refining & Petrochemical, Architecture & Construction etc.
Sizes (inch) | OD (mm) | Slot (mm) | Length (m) | Tenslie Strength | Collapse Strength | Wrap wire Vee-shaped wire(mm) | Support rod Round wire(mm) |
3-1/2 | 88.9 | 1.0 | 2.9 | >22 | 10.2 | 2.2x3.5 (Widthxheight) | ø3.8MM×22 |
4-1/2 | 114.3 | 1.0 | 2.9 | >28 | 11.5 | 2.2x3.5 (WxH) | ø3.8MM×22 |
6-5/8 | 168.3 | 0.75 | 5.8 | >40 | 12.8 | 2.2x3.5 (W x H) | ø3.8MM×32 |
6-5/8 | 168.3 | 1.0 | 5.8 | >33 | 12.8 | 2.2x3.5 (W x H) | ø3.8MM×32 |
6-5/8 | 168.3 | 0.63 | 5.8 | >83 | 45 | 3.2x6.0 (W x H) | ø6.0MM×32 |
8-5/8 | 219.1 | 1.0 | 5.8 | >34 | 21.9 | 2.3x3.5 (W x H) | ø3.8MM×48 |
8-5/8 | 219.1 | 1.0 | 5.8 | >50 | 38.2 | 3.0x5.0 (W x H) | ø4.0MM×48 |
8-5/8 | 219.1 | 1.0 | 5.8 | >60 | 46 | 3.2x6.0 (W x H) | ø5.0MM×48 |
10-3/4 | 273.1 | 0.75 | 5.8 | >50 | 32.9 | 2.2x3.5 (W x H) | ø4.0MM×55 |
10-3/4 | 273.1 | 1.0 | 5.8 | >60 | 39.5 | 3.0x4.6 (W x H) | ø4.8MM×55 |
10-3/4 | 273.1 | 1.0 | 5.8 | >100 | 48 | 3.2x6.0 (W x H) | ø5.0MM×55 |
12-3/4 | 323.9 | 1.0 | 5.8 | >120 | 37.2 | 3.0x5.0 (W x H) | ø4.0MM×56 |
14 | 355.6 | 1.0 | 2.9 | >80 | 37.8 | 3.0x5.0 (W x H) | ø4.0MM×59 |
16 | 426 | 1.0 | 2.9 | >80 | 37.5 | 3.0x5.0 (W x H) | ø4.0MM×54 |
Product Tags: continuous slot johnson v wire screen pipe, flow rate johnson wire screen, slotted johnson wire screen tube